2005 Zafira 1.9dt DPF

[Lexas]

Someone cut out dpf filter and lost it :D can someone make it off manual solution, please. ecusafe and volta not worked. zafira 1.9dt 0281012549

[pulsar2000]

"Someone cut out dpf filter and lost it :D"
Happens every time lol......

ecu safe works perfect , although you lose your DTC Tables. you tried disconnecting pressure sensor by bulkhead, never had a issue and done over 30.....

[Lexas]

after ecu safe car is still in limp mode. only difference that engine light not comes up.

[morgano]

Hello.

Hope this solves problem ;)

[Lexas]

Thank You! I'll try and let you know.

[morgano]

Need all sensors ok and in place. ;)

[Lexas]

But one sensor is missing i think. the dpf filter was cut out next door garage and laying on the floor, after someone just steal it. so filter is totaly missing and guy who cut it out said that there was one sensor on filter, now there is one plug not connected... is that bad? i mean there is no filter at all now, just pipe welded in between :D and two pipes not connected too, i think it for regeneration fluid?

[pulsar2000]

you got other issues with car, if just dpf, trust me ecu safe works a treat,,,,
you read dtc ?
sounds more problem than dpf...

[Lexas]

Hello.

Hope this solves problem ;)

with your dump im getting one fault: exhaust gas temperature sensor. Its because that sensor is missing... after start car works good for 30 seconds after goest to limp mode and RPM only till 2000. Is it possible to bypass this sensor with resistor or anything else?

[mb7361]

try this and report BR

[morgano]

with your dump im getting one fault: exhaust gas temperature sensor. Its because that sensor is missing... after start car works good for 30 seconds after goest to limp mode and RPM only till 2000. Is it possible to bypass this sensor with resistor or anything else?

Tell me DTC number Pxxxx ;)

[Prime]

Hi Bro
take my solution
DPF OFF all sensor disconnect connector
egr off disconnect connector

[Lexas]

Hi Bro
DPF OFF all sensor disconnect connector
egr off disconnect connector
Thank you mate, you solution worked perfect!

mb7361 (http://www.digital-kaos.co.uk/forums/member.php/76234-mb7361)
didnt try your dump, but thanks anyway!

[trevormaharaj]

hi i got a zafira where the dpf filter was removed can someone help me with a solution please
i read the ecu flash with fj tech
ecu no 0 281 012 549
thanks