PDA

View Full Version : peugeot 307 dpf egr off



yeager
9th December, 2016, 03:49 PM
hi
i try turn off dpf and egr on this car whit volta, after i make it, there was no dtc but car was in limp mode ... later i try manual solution, biut too many dtc after this solution .... now is in car other manual solution, no dtc but rpm only max 3000 ... i try connect disconnect all sensors same result, can anyone help me whit this problem?
307 edc16c39, whit aditiv

filetuning
9th December, 2016, 04:04 PM
original file??????

yeager
9th December, 2016, 06:10 PM
This is original, i read this from car ... Dont have other ...

yeager
10th December, 2016, 06:14 PM
Noone can help? :(

pike
11th December, 2016, 12:05 AM
Hi,
specify all DTC's

yeager
11th December, 2016, 09:55 AM
Diesel (9HZ (VIN 6-8 = Engine code) - EDC16C3 - MT/AT)
DTC Description
P1445 - Additive system,quantity of additive too high
- Permanent
P2408 - Additive system; fuel filler cap present sensor fault
- Permanent
P0409 - EGR solenoid valve circuit, component blocked
- Permanent
P0473 - Differential exhaust gas pressure signal
- Short circuit to positive
- Permanent
P2033 - Particle filter upstream temperature signal; temperature too low
- Permanent
P2124 - Charging air cooler bypass butterfly solenoid valve
- Permanent
P0243 - Turbo Wastegate
- Permanent
P1351 - Preheating relay circuit, relay controlled and glow plugs not supplied
- Permanent
Fault codes

bodzio012
11th December, 2016, 10:38 AM
Tried like this???
Pass PM

pike
11th December, 2016, 12:06 PM
File egr dpf off. You can disconnect egr valve, differential pressure sensor and temperature sensor.

yeager
17th December, 2016, 11:04 AM
first i write pike file ... whenn i push accelleratol pedal to full ... rpm stop for a second on 3000 then go up to 5000
customer make whit car 100km, all was ok, but after again limp mode, restart car not help ... after make 50km again work all without problem ...
DTC Description
P1351 - Preheating relay circuit, relay controlled and glow plugs not supplied
- Permanent
P1445 - Additive system,quantity of additive too high
- Permanent
P2408 - Additive system; fuel filler cap present sensor fault
- Permanent
P2124 - Charging air cooler bypass butterfly solenoid valve
- Intermittent
P0243 - Turbo Wastegate
- Intermittent
P1614 - Accelerator pedal sensor - speed limiter
- no signal
- Intermittent

now go test bodzio012 file ...

yeager
10th January, 2017, 04:40 PM
whit bodzio12 file i get this errors

P1351 - Preheating relay circuit, relay controlled and glow plugs not supplied
- Permanent
P1445 - Additive system,quantity of additive too high
- Permanent
P2408 - Additive system; fuel filler cap present sensor fault
- Permanent
P2124 - Charging air cooler bypass butterfly solenoid valve
- Intermittent
P0243 - Turbo Wastegate
- Intermittent
P0473 - Differential exhaust gas pressure signal
- Short circuit to positive
- Permanent
P2033 - Particle filter upstream temperature signal; temperature too low
- Permanent
P0470 - Differential exhaust gas pressure signal
- Coherence
- Permanent
Fault codes

is not possible turn it off permanently?

pike
10th January, 2017, 06:05 PM
Hi again.

I added additive off, solution must be working.

yeager
10th January, 2017, 08:22 PM
What all i need disconnect?

cport
10th January, 2017, 08:24 PM
Eeprom is problem.
I have solution. :)

pike
10th January, 2017, 08:32 PM
What all i need disconnect?

No difference.

yeager
11th January, 2017, 05:07 PM
Is adblue in thus car? I dont find it ... Its not must be disconnected?

yeager
12th January, 2017, 03:35 PM
pike where is file?

AGDiag
12th January, 2017, 03:37 PM
@yeager doesn't the ori file that you've read and posted have already EGR Off? I can see that the EGR Hysteresis maps are already canceled

yeager
12th January, 2017, 05:37 PM
I dont know, customer come to me, for egr and dpf off there was dtc egr and dtc dpf ...

pike
12th January, 2017, 05:51 PM
pike where is file?

I ate it for dinner.

AGDiag
12th January, 2017, 06:02 PM
it seems to me like someone else before you tried to do EGR Off

yeager
12th January, 2017, 07:36 PM
I ate it for dinner.
But realy, you delete it? I dont see it ...

AGDiag
13th January, 2017, 04:23 PM
try this...

yeager
13th January, 2017, 08:32 PM
Monday i can try it, hope it will work ... I try more versions but no success ...

yeager
16th January, 2017, 03:36 PM
@AGDiag
after write your file, 3 dtcs present

DTC Description
P2124 - Charging air cooler bypass butterfly solenoid valve
- Permanent
P0243 - Turbo Wastegate
- Permanent
P0470 - Differential exhaust gas pressure signal
- Coherence
- Permanent
Fault codes

One is egr, maybe not turned off properly ...

AGDiag
16th January, 2017, 05:33 PM
second try... same pass

yeager
16th January, 2017, 06:03 PM
Ok, will try tomorrow ...

yeager
20th January, 2017, 02:47 PM
I try it now, car dont start whit this file ...

pike
20th January, 2017, 03:34 PM
Hi again.
The first thing you need - write original firmware file in ECU, then the second - to see DTCs and decide what's the problem.

yeager
22nd January, 2017, 09:38 AM
In #6 post i sent all dtcs whit original soft ...

yeager
2nd February, 2017, 06:17 PM
Anyone can help me? :(

yeager
3rd February, 2017, 08:45 AM
I dont need it free, can pay for working solution ...

gyapi11
3rd February, 2017, 11:25 AM
Hi.What do you use / writing, reading /

yeager
7th February, 2017, 11:56 AM
I use gal2 eu clone ... Obd2

unnamed11112007
7th February, 2017, 10:09 PM
Hi "yeager"! you have a problem with car, I think with the ECU or eeprom, no need to remove all the errors in a row, you will not be happy, car did not IMMO off or replaced ECU?

pagautas
8th February, 2017, 07:31 AM
Yeager, post photo of ecu sticker. And it would be great full bdm dump.

Sent from my Nexus 5X using Tapatalk

yeager
8th February, 2017, 08:33 AM
Hi "yeager"! you have a problem with car, I think with the ECU or eeprom, no need to remove all the errors in a row, you will not be happy, car did not IMMO off or replaced ECU?
Dont know about ecu replacement or immo off

sonic 1989
8th February, 2017, 08:09 PM
PLEASE TESTED REPORT


TESTED 20 time

yeager
8th February, 2017, 08:31 PM
Thx, tomorrow can try ...

Act Tuning
8th February, 2017, 08:38 PM
I didnt read all this thread but PSA Edc16C34 and 3 pages on thread, you may have problem on the car as this is very easy ecu to mod dpf egr and tune,

yeager
10th February, 2017, 05:11 PM
PLEASE TESTED REPORT


TESTED 20 time

Hope it will be ok, i write thus file and first time i dont have dtc egr ir dpf, only turbo ...

sonic 1989
11th February, 2017, 09:17 AM
i you not understood,i you helped???

yeager
11th February, 2017, 06:38 PM
Think yes ... Before when i write files or i dont have dtcs or i have all dtcs include dpf ... Whit your file is other situation ... Dobt have dpf dtcs, but only dtc about turbo pressure ... I think car have turbo problem ...

sonic 1989
12th February, 2017, 12:06 PM
If I helped you add reputation+thanks