IBIZA 2002 1,9 TDI PD

**erikfrog** · 26th December, 2009, 10:31 PM

Hi i?m lookink for wiring diag. of power distribution of this car. I have problem that fuse (18)from instrument cluster blow in few seconds also fuse for reversing lights (19). And without power in cluster car will not start because immo module is off.

**Meat-Head** · 26th December, 2009, 10:40 PM

start with unplug the reverse light switch.

check the vechile horn, just incase these items have gone down to earf.

**erikfrog** · 26th December, 2009, 11:02 PM

Fuse from reversing lights was blowed for a long time. And today my friend have replaced it. And this was start of problems. I will check light switch and horn tomorrow and I?ll write report.

**erikfrog** · 27th December, 2009, 01:00 PM

Disconnected dash,clima, reversing light switch, horn.... still 19A on fuse no.18.
Wiring diagram show what else is on this fuse. Any help?

**Meat-Head** · 27th December, 2009, 01:07 PM

Originally Posted by erikfrog

Disconnected dash,clima, reversing light switch, horn.... still 19A on fuse no.18.
Wiring diagram show what else is on this fuse. Any help?

un-plug ciggerette lighter

check around the gas pedal no wires have chaffed.

do the front and rear wipers still work?
do a full test of lights etc and see what doesn't work.

**erikfrog** · 27th December, 2009, 07:08 PM

still nothing everything works. But I have checked next fuse 19 (reversing lights) after disconnecting rev. lamp and switch fuse blown...
So there must be something that have these two fuses together. Both wires go somewehere in the middle or right side of the dash.
As i have written problems came after replacing rev lights fuse. And I think that this wire has damaged (melted)isolation somewhere...

**Meat-Head** · 27th December, 2009, 07:39 PM

Originally Posted by erikfrog

still nothing everything works. But I have checked next fuse 19 (reversing lights) after disconnecting rev. lamp and switch fuse blown...
So there must be something that have these two fuses together. Both wires go somewehere in the middle or right side of the dash.
As i have written problems came after replacing rev lights fuse. And I think that this wire has damaged (melted)isolation somewhere...

if you put a 55 watt bulb instead of a fuse, as you find the fault the light will go out saving you a fortune in fuses.

look at the ends of the wires, where the oxygen is, if encased wires do not normally burn due to no air.

**MOBILTRONIC** · 27th December, 2009, 11:26 PM

If the problem is performed when replacing the switch reverse lights, there should be and start and stop lamps to see if there some problems.Check installation problem in mind that the accident was not burnt part and stick the two cables, not the vehicle and hit someone accidentally screw in doorstep and into installation ... I hope that you will draw something from this.

**Ashraf6119** · 27th December, 2009, 11:32 PM

Hi

Fuse F18 is 10amp is for A/C, Heater Recirculation, Electric heated Door Mirrors,Head lamp Adjustment, Instrument panel, and Navigation System.

Fuse F19 10amp is for Heated Windsceern, Washer Jet, and Reversing lamp.

So worth checking all those system connected to this two fuses.

Also check the bulbs if they are right one fitted.

Hope This Helps

Ash

**Babanovski** · 28th December, 2009, 12:05 AM

tray to disconnect the wiring for rear boot. and replace the fuse

**erikfrog** · 28th December, 2009, 08:13 AM

Originally Posted by Babanovski

tray to disconnect the wiring for rear boot. and replace the fuse

Is somewhere plug?

**erikfrog** · 28th December, 2009, 08:16 AM

Originally Posted by Ashraf6119

Hi

Fuse F18 is 10amp is for A/C, Heater Recirculation, Electric heated Door Mirrors,Head lamp Adjustment, Instrument panel, and Navigation System.

Fuse F19 10amp is for Heated Windsceern, Washer Jet, and Reversing lamp.

So worth checking all those system connected to this two fuses.

Also check the bulbs if they are right one fitted.

Hope This Helps

Ash

Disconnected Dash, Climatronik, Headlamp adjustment, reversing lights, Mirrors.
Continue today.

**Ashraf6119** · 28th December, 2009, 10:21 AM

Hi

Have you checked the wirings back of the fuse box ?

Ash

**Meat-Head** · 28th December, 2009, 10:30 AM

Originally Posted by erikfrog

Disconnected Dash, Climatronik, Headlamp adjustment, reversing lights, Mirrors.
Continue today.

unplug the washer jets and make sure it has chaffed on the bonnet hinge.

or for 10 seconds keep the fuse linked out and stop the instant you see smoke (bad idea, but needs must!)